Although air conditioning dripping condensate is very common for people, it brings inconvenience to people, affects the environment, makes buildings unsightly, and sometimes causes embarrassing situations to people. It can be said that condensate water treatment is a realistic problem. The state has taken many measures in this regard. For example, the Ministry of Construction stipulates that air conditioning condensate drain pipes should be embedded in new houses in the future, which not only increases the cost of houses, but also makes the buildings less beautiful. At the same time, some cities expressly stipulate that air-conditioning dripping water cannot flow casually, and a drainage pipe must be connected downstairs, which cannot affect people's lives. The outer protective screen of the outdoor unit of the air conditioner is made into an evaporation filter screen with water storage and water distribution functions. The net has smaller wind resistance and larger surface area, and the condensed water led to the net is dried by the air cooling the air conditioner, thus solving the problem of discharging the condensed water of the air conditioner, reducing the temperature of the cooling air and improving the refrigeration capacity of the air conditioner. Air conditioning filter evaporator can not only treat condensed water, but also improve the energy efficiency ratio and refrigeration capacity of air conditioning. According to the test of Hisense Air Conditioning National Accreditation Laboratory, after installing air conditioning filter evaporator, the refrigeration capacity of air conditioning can be increased by 2.3 1%, and the energy efficiency ratio of air conditioning can be increased by 2.02%. The upper part of the air-conditioning filter evaporator is provided with a water distribution device, and the water distribution device is provided with a flow adjusting splint, and the air-conditioning filter evaporator is provided with a condensed water filter. The evaporator uses the wind cooling the air conditioner to evaporate the filtered water of the condensed water, and the condensed water is introduced into the net through the filter made of reticular water-absorbing material to realize the treatment of the condensed water. The air conditioner condensate water treatment composite filter evaporator is a grid structure device assembled on outdoor air conditioners, and is installed on both sides of an air-cooled condenser by a water diversion pipe, a water distributor, a hydrophilic water-absorbing air net with high mechanical strength, an air conditioner external filter evaporator, an air conditioner internal filter evaporator, a water tank, a water diversion pipe groove, an air conditioner external filter evaporator and an air conditioner internal filter evaporator. The outer filter evaporator of the air conditioner is prior to the inner filter evaporator of the air conditioner in water distribution, the two air nets of the inner filter evaporator and the outer filter evaporator are provided with horizontally distributed water tanks, and a communication pipe or water tank composed of hydrophilic water-absorbing materials is correspondingly arranged between the water tanks of the air nets of the two filter evaporators, so that water flows from the water tank of the outer filter evaporator of the air conditioner to the water tank of the inner filter evaporator of the air conditioner; Or another kind of water distributor of composite filter evaporator which can automatically regulate and control the treatment of air-conditioning condensate water, including air-conditioning condensate water diversion pipe, water float control valve, air-conditioning external filter evaporator water diversion pipe connected with the valve, water distributor, hydrophilic evaporation air net, water collecting tank, water collecting tank and water storage tank, water float matched with water storage tank, guide rod connected with water float valve, air-conditioning internal filter evaporator water diversion pipe connected with the valve, water distributor, hydrophilic evaporation air net and water collecting tank. The air conditioner external filter evaporator and the air conditioner internal filter evaporator are installed on both sides of the air-cooled condenser. The condensed water of air conditioner is introduced into the valve with opposite switch controlled by the floating connecting guide rod through the pipeline. The valve between the air-conditioning condensate diversion pipe and the evaporator diversion pipe of the air-conditioning outdoor unit is in a normally open state, and the valve between the air-conditioning condensate diversion pipe and the evaporator diversion pipe of the air-conditioning indoor unit is in a normally closed state. A water inlet and a water outlet at the bottom of the water tank side installed with a water float are connected with the water tank at the bottom of the internal and external filter evaporator of the air conditioner through pipelines or combined with a pipe groove of hydrophilic water-absorbing material. Air-conditioning filter evaporator is a condensation external protective net with condensate water treatment function. Compared with the original outer protective net, it has the characteristics of water storage and water distribution, and the mesh structure is rhombic to ensure its water distribution and uniformity. (1) In normal weather, due to the high air temperature, low humidity and strong air evaporation capacity, the filter evaporator outside the air conditioner gives priority to water distribution, and the water preferentially distributed on the evaporation net is continuously evaporated under the action of induced wind. When it reaches the adjustable throttling water tank installed on the evaporation net of the air conditioner, not much water is separated, and the water evaporates rapidly along the suction net, and the reduced air rises in temperature after passing through the air-cooled condenser, and then passes through the air conditioner. After treatment, the condensed water of air conditioner reduces the temperature of air, improves the cooling of condenser and improves the refrigeration capacity of air conditioner. (2) When the air humidity is high, the water on the filter evaporator outside the air conditioner cannot be completely evaporated. The water reaches the throttle sump installed in the proper position of the air net, and part of the water evaporates along the air net, and the other part of the water enters the throttle sump of the filter evaporator inside the air conditioner through the conduit, and the water is distributed to the filter evaporator inside the air conditioner, diffused under the action of capillary suction, evaporated and dried by the hot air heated by the air-cooled condenser and discharged. (3) When the air humidity is high, water cannot be completely evaporated on the filter evaporator outside the air conditioner. The water reaches the throttle slot installed in the proper position of the air net, and a part of the water evaporates downward along the air net. The other part of water enters the filter evaporator inside the air conditioner through the conduit, is distributed to the filter evaporator inside the air conditioner, diffuses under the action of capillary suction, and is evaporated and dried by hot air heated by the air-cooled condenser, and then discharged. Because water can't completely evaporate on the filter evaporator outside the air conditioner, it reaches the bottom tank of the filter evaporator outside the air conditioner along the air net, and the water can flow from the filter evaporator tank outside the air conditioner to the bottom tank of the filter evaporator inside the air conditioner through the corresponding communication pipe between the air net tanks of the two filter evaporators or the water tank combined with hydrophilic water-absorbing materials. The water storage material absorbs water, diffuses under the action of capillary suction, and is dried by the hot air heated by the air-cooled condenser, thus realizing the evaporation of condensed water and improving the cooling of the air conditioner. The other route is composed of an air-conditioning external filter evaporator, an air-conditioning internal filter evaporator, an air-conditioning condensed water introduction duct, a three-way valve, a water storage tank, a water float with a guide rod and the like, which are installed on both sides of the air-cooled condenser of the air conditioner. The external filter evaporator of air conditioner is installed on the air conditioner shell as the external protective net of air conditioner condensate processor and air-cooled condenser. The filter evaporator in the air conditioner is installed on the inner side of the air conditioner condenser, which is used to evaporate the air conditioner condensate that cannot be evaporated by the outer evaporation air net. The internal and external water distribution and hydrophilic evaporation air net are connected with the air conditioning condensate introduction duct, which is provided with a three-way control valve; The bottom grooves of the inner and outer filter evaporator air nets on both sides of the condenser are connected with the water storage tank between them through conduits, and a water float is arranged in the water storage tank, and a guide rod is arranged on the water float to control the opening and closing of the three-way valve. The condensed water of air conditioner enters the three-way valve through the diversion pipe, and is divided into two paths, which are respectively connected with the water distributors of the internal and external filter evaporators. (1) Under normal weather conditions, the three-way valve connecting the filter evaporator and the water distribution pipe with the external air conditioner is in the open state, and the three-way valve connecting the filter evaporator and the water distribution pipe with the internal air conditioner is in the closed state. The condensed water of the air conditioner reaches the three-way valve through the diversion pipe, flows to the water distribution pipe of the external filter evaporator of the air conditioner through the opened valve, is evenly distributed on the external water distribution hydrophilic evaporation air net, and is continuously evaporated under the action of induced air, and the air with increased temperature is discharged after passing through the internal water distribution hydrophilic evaporation air net. After treatment, the condensed water of air conditioner reduces the temperature of air, improves the cooling of condenser and improves the refrigeration capacity of air conditioner. (2) When the air humidity is high, water cannot completely evaporate on the external water distribution and hydrophilic evaporation air net, but reaches the water tank at the bottom of the net, enters the bottom water storage tank through the conduit, and flows into the water tank through the conduit connected with the internal water distribution and hydrophilic evaporation air net. Under the action of capillary suction, the water storage material at the bottom sucks water out and is dried by the hot air heated by the air-cooled condenser. (3) When the air humidity is very high, the three-way valve connecting the filter evaporator and the water distribution pipe outside the air conditioner is in the open state, and the three-way valve connecting the filter evaporator and the water distribution pipe inside the air conditioner is in the closed state. The condensed water evaporated by the external filter evaporator of air conditioner is less, and a large amount of condensed water reaches the bottom water storage cavity through the external water distribution and hydrophilic evaporation air net. Water flows into the water storage tank between the two water distribution and hydrophilic evaporation air nets through the conduit, so that the water in the water storage tank increases and the water level rises. The water float in the water tank floats, and the guide rod located on the float pushes the three-way valve upward, opening the valve leading to the internal filter evaporator of air conditioner and closing the valve leading to the external filter evaporator of air conditioner. So as to automatically control to achieve balance, so that the condensed water of the air conditioner leading to the water pipe of the inner distribution water and the hydrophilic evaporation mesh cloth is increased, and the condensed water leading to the outer distribution water and the hydrophilic evaporation mesh cloth is reduced until it disappears. In this way, the water is evenly distributed to the filter evaporator in the air conditioner through the water distribution pipe, and after being heated by the air-cooled condenser, it is quickly dried under the action of hot air with greatly reduced humidity, thus ensuring that the air conditioner will not drip water under any refrigeration condition.
What is an air conditioner evaporator? Where is the air conditioner? The following is about which is better, the fixed frequency air conditioner or the variable frequency air conditioner, what is the reason for the air conditioner dripping, and how the air conditioner drips. Butt the copper tube, the center line of the butt copper tube is in a line, screw the nut by hand until it can't turn, and then screw the contaminated part with a wrench; The cleaning of the second filter is the most important part of the core; Check the original post of the third condenser and evaporator >:>
What is a double evaporator air conditioner? Double evaporator is a compressor with two evaporators, which is used for refrigeration.
The function of air conditioner evaporator is to use liquid low-temperature refrigerant to evaporate easily at low pressure and convert it into steam to absorb the heat of the cooled medium, so as to achieve the purpose of refrigeration.
What is the material of the air conditioner evaporator? The air conditioner evaporator is made of copper tube, aluminum fiber alloy, fins and other materials.
The role of air conditioner evaporator:
The evaporator and outdoor cold water shower together form gas-liquid conversion to realize cold and heat exchange. The cold-hot conversion of air conditioner is actually the direction of refrigerant medium flow, and the time to complete this function is the electromagnetic four-way valve. Is the exchange of indoor and outdoor machines.
What metal is the evaporator of TCL air conditioner made of? A device for supplying process air to a space area (usually enclosed). Its function is to adjust the temperature, humidity, cleanliness and air flow of indoor (or enclosed space or area) air to meet the requirements of human comfort or technological process. [Edit this paragraph] Working principle The compressor compresses the gaseous refrigerant into a high-temperature and high-pressure liquid refrigerant, and then sends it to the condenser (outdoor unit) for heat dissipation, which becomes a normal-temperature and high-pressure liquid refrigerant, so the outdoor unit blows out hot air.
Then enter the capillary and enter the evaporator (indoor unit). Because the space suddenly increases and the pressure decreases after the refrigerant reaches the evaporator from the capillary, the liquid refrigerant will vaporize and become a low-temperature gaseous refrigerant, thus absorbing a lot of heat, and the evaporator will become cold. The fan of the indoor unit blows out indoor air from the evaporator, so the indoor unit blows out cold air. Water vapor in the air will condense into water droplets when it meets a cold evaporator and flow out along the water pipe, which is why air conditioners produce water.
Then the gaseous refrigerant returns to the compressor to continue compression and circulation.
When heating, there is a component called four-way valve, which makes the refrigerant flow in the condenser and evaporator in the opposite direction to that during refrigeration, so when heating, cold air is blown to the outside and hot air is blown to the room.
In fact, it is the principle that junior high school physics has learned that heat is discharged when liquefied (from gas to liquid) and heat is absorbed when vaporized (from liquid to gas). [Edit this paragraph] The invention of air conditioning The British inventor Willis haviland Kelly 1902, known as the father of refrigeration, designed and installed the first air conditioning system. The air conditioning system was designed for a printer in new york, USA. He found that the change of temperature would cause the deformation of paper, which would lead to the imbalance of color ink. Carrier registered the patent 1906.
What is the evaporator of the central air conditioner? The scope of central air conditioning is too wide, and the evaporator of VRV is an indoor unit, which looks like a coil. The evaporator of the chiller is just a thick pipe.
What is the problem that the evaporator of air conditioner does not frost? Under normal circumstances, the evaporator of air conditioner will not frost. Frost will only form when the refrigerant is insufficient.
Where is the evaporator of the car air conditioner? Is it next to the air-conditioned car? Generally speaking, its position is above the position where the co-pilot puts his feet.
That large screen is called the air intake grille, which is used to collect the cooling air from the automobile water tank and air conditioner condenser.